|
SPRAY ADHESIVE QS
900 is a fast tacking,
non-chlorinated spray adhesive. This specialist formulation will
provide instant ‘grab’, which allows pressure to be exerted on the bond
before full cure strength is achieved.
ADVANTAGES
* Quick stick - provides instant grab
* Provides permanent bonds
* Free from chlorinated solvents
* Tack time approximately 30 seconds
* Economical in use - only a light film is required for instant grab
APPLICATIONS
QS 900 Quick Stick Adhesive has been formulated to satisfy the
demands of the carpeting and flooring trade. It is also suitable for
bonding many different substrates, including:-
* Carpet * Underlay * Foam * Fabric * Cork
* Upholstery * Paper, Cardboard * Wood
To a wide variety of different surfaces.
Apply a light, fine even coating to both surfaces to be bonded from
9" - 12" (25 - 30 cm). Wait until the adhesive is tack-dry and bond the
surfaces together using firm pressure.
Heavier applications
of QS 900
may prolong the tack time. N.B. May
affect certain plastics. Always test a small, inconspicuous area before
general use. To prevent blockages, invert the can after use and spray to
clear the nozzle.
TECHNICAL DATA
Appearance : Clear, amber liquid
Odour : Characteristic Solvent
SG @ 25°C : 0.66
Pressure @ 25°C : 4 Bar
Discharge rate : 1.2 g/sec
Polymer type : Styrene Butadiene Rubber
Tack time : Approximately 30 seconds
Bonding time : Maximum adhesion in 12/24 hours
Temperature range : Up to 50°C (dried film)
Solubility : Soluble in some solvents, insoluble in water
Recommended solvents : Amberklene FE10, ME20
Flammability : Classified as extremely flammable under
CHIP Regulations
Packaging : 500ml aerosol (12 per carton)
STORAGE
The product may be stored at normal ambient temperatures and has
a shelf life of not less than 12 months with correct storage. Aerosols
should always be stored below 50OC, away from direct heat and naked
flame. |
